Often asked: How To Change The Stator On A 07 Road King Harley Davidson?
- 1 How long does it take to replace a stator on a Harley?
- 2 How hard is it to change a stator?
- 3 How much does Harley charge to replace a stator?
- 4 What are the symptoms of a bad stator on a Harley Davidson?
- 5 What would cause a stator to go bad?
- 6 How long does it take to replace a stator?
- 7 How do I know if my stator or rectifier is bad?
- 8 How much does it cost to replace a belt on a Harley?
- 9 How much does it cost to have a stator replaced?
- 10 Can you ride a Harley with a bad stator?
- 11 What causes a Harley stator to burn out?
- 12 Can you clean a stator?
How long does it take to replace a stator on a Harley?
You should be able to get in and out under 3 hours.
How hard is it to change a stator?
Replacing the stator is not too complicated and requires a socket set and some heat resistant gasket repair silicone only. On 2006-07 Honda Fireblades the stator is located on the left hand side behind the crash protector.
How much does Harley charge to replace a stator?
5,000 service ’14 Ultra Limited, $397 with synthetics. ’05 Heritage Classic stator replacement, $115.
What are the symptoms of a bad stator on a Harley Davidson?
The most obvious symptoms of a bad motorcycle stator include no spark, weak spark, or intermittent spark (also known as misfiring). Hard starts and a poorly running engine can also be clues that your stator needs to be rebuilt or replaced.
What would cause a stator to go bad?
There are a few things that may cause a stator to fail. Too heavy of a load when operating accessories (winch,heated grips,headlights, etc). If working several of these items at one time (plowing/pulling/possibly stuck at night) you would overload the system. This could cause either the stator or rectifier to fry.
How long does it take to replace a stator?
A good tech can change a stator in 3 hours and a belt in 6 or 7 hours. Your belt should go over 100,000 if it has been properly maintained.
How do I know if my stator or rectifier is bad?
Key Signs to Look For You won’t have any trouble diagnosing the faulty regulator rectifier if the battery is the cause. You’ll note signs right away like poor starts, fluctuating meter readings, and dimmed headlights. around 13 volts, the bike will start to drain the battery.
How much does it cost to replace a belt on a Harley?
Harley drive belts are very strong and durable and only need replacement after thousands of miles of riding. Unless you have a warranty, a replacement will cost a few hundred dollars at your Harley dealer. Do it yourself in about 30 minutes, for less than $50.
How much does it cost to have a stator replaced?
Stator & Rotor A new stator and rotor set typically costs between $250 and $1,500. They are stationary and rotating parts of any system that generates electricity. When they stop working seamlessly, they need repair or replacement.
Can you ride a Harley with a bad stator?
Battery: The stator system charges your battery and replenishes it. You could actually run your motorcycle just fine for some time without a working stator as the battery has reserve current. Of course, the battery would eventually die.
What causes a Harley stator to burn out?
This voltage can be thousands of volts from just a 12 volt circuit. That high voltage spike can punch through the enamel insulation in the stator coils and cause them to short out.
Can you clean a stator?
Clean the stator by spraying or brushing on with mineral spirits and follow with wiping and blowing out with compressed air. Let it dry over night before applying your sealant. Mineral spirits will not damage your paint nor the winding coatings and is just a very good cleaning and degreasing product.